My 97 Aerostar 3.0L has developed a wierd problem. When it is cold (below
-10 degC) it will not start. When I turn the key on, I hear the fuel pump
relay click but do not hear the fuel pump. Also the light for the
overdrive displays off. At first I thought the gas line was frozen but
that isn't the problem. If I plug the block heater in for a couple of
hours, it will start right up. Also the off light for the overdrive is not
on and of course I hear the fuel pump when the key is first turned on.

Any ideas what might be causing this? It runs great after it starts.

Thanks in advance

Now the thing won't start even with plugging it in. On other thing I notice
is the check engine light does not come on when the key is first turned on
and when a code reader is attached no codes are displayed.

"Ron2_1" <ron2_1 (AT) nospam (DOT) hotmail.com> wrote

Does the engine even turn over?

Yes the engine turns over no problem

I had a similar problem with intermintent failure with starting. what i
found was a little electrical connector (black 90 degree) under the hood
on the driver side wall close to the windsheild was slightly rusted. I
simply sanded off the rust,put a little WD40 and slightly crimped it to
prevent it from vibrating loose. Since then my aerostar has started every
time in all weather. I wish i could find another new 97, would buy it
instantly! Hope this works for you..

ALD

Found the problem
Was the Air Intake Temperature Sensor. Seems to be ok now after changing
that.
I have to agree witn you Dale. It has been excellent and I would not
hesitate on purchasing another